alternator tests ok on bench but does not put ou any voltage when run through the wiring harness?

25

Asked by jstkrusin Sep 14, 2007 at 11:17 PM

Question type: Maintenance & Repair

tach, speedo and temp guage don't function all fuses
ok any clues as to where to look appreciated figure the ecu may be wacked out

84,405

littlehorn answered 17 years ago

Could be the ECM, or it could very well be a short in the wiring harness leading the alternator not to charge. Try replacing or testing the battery -- Many newer alternators WILL NOT put out a charge if the battery is at less than 12 volts. This is a safety feature to ensure that the alternator doesn't burn itself out trying to charge a dead battery. This might also explain lack of dash component function.

Mark helpful

25

jstkrusin answered 17 years ago

put hot battery in 12.6 volts. tach and speedo went away before battery went dead will ring out the wiring and I have another ecu comming Thanks

Mark helpful

Your Answer:

alternator tests ok on bench but does not put ou any voltage when run through the wiring harness? 2 Answers

tach, speedo and temp guage don't function all fuses ok any clues as to where to look appreciated figure the ecu may be wacked out

Nissan

-

Maintenance & Repair
I have an 87 D21 Nissan truck it will start and run but just a second then stop firing you can leave it over night and it will crank again. I have changed the coil got the same thing. I checked the voltage to the coil with switch on its 12.95 volts when turning over it goes down to 9.5 volts. any suggestions ? 5 Answers

I have an 87 D21 Nissan truck it will start and run but just a second then stop firing you can leave it over night and it will crank again. I have changed the coil got the same thing. I checked the vo...

1987 Nissan Pickup

-

Maintenance & Repair
Wiring harness 2 Answers

I have a 93 nissan truck 4 wheel drive manual 4 cylinder fuel injection I'm having trouble getting it to run when u dump fuel down the throttle body it runs tell the fuel is burned out other than ...

1993 Nissan Pickup

-

Maintenance & Repair
Can't get any fire in my Pathfinder. I have checked distributer cap, coil, plugs, wiring, and power transister. It will roll over but won't run. I had it running one day for a while, and now it won't go. At the end of my rope ready to call the junk guy. Any ideas on what I can check out next? 7 Answers

I have checked distributer cap, coil, plugs, wiring, relays and power transister. It will roll over but won't run. I had it running one day for a while, and now it won't go. I'm at the end of my rope,...

1992 Nissan Pathfinder

-

Maintenance & Repair
Just had the alternator replaced on an otherwise great car. However I noticed prior to the radio and speedometer which zeroed when the electrical problem 1st arose last week, the speedometer would occasionally get stuck at 60km/h and then unstick to 100km/h. Probably 2 different problems. Now this 276000km car has a refurbished alternator but early mornings after sitting through a cold night for several hours, the radio and wipers don't work, until she heats up!?! Any ideas why that happens ...could a relay be responsible for this heat sensitive issue? Please advise 2 Answers

Just had the alternator replaced on an otherwise great car. However I noticed prior to the radio and speedometer which zeroed when the electrical problem 1st arose last week, the speedometer would oc...

Nissan

-

Maintenance & Repair

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.