replacing motor in 3.5 Montero Sport

Asked by Hurley63 Oct 03, 2015 at 07:43 PM about the 2003 Mitsubishi Montero Sport

Question type: Maintenance & Repair

motor turns over manually when bolted up loosely, but as soon as I tighten up  
the bolts to the tranny the motor locks up and won't turn over.

1 Answer
1,405

dsmittymastermechani... answered 9 years ago

make sure the torque converter is in the tranmission all the way , spin it several times around , and make sure the studs on the torque converter are going in the holes on the flywheel , be careful , the transmission pump breaks very easy if its not all the way in the tranny, if this is not it , makes sure everything is correct to the vehicle, good luck

1 people found this helpful.
Mark helpful

Your Answer:

Related Questions

  • replacing motor in 3.5 Montero Sport 1 Answer

    motor turns over manually when bolted up loosely, but as soon as I tighten up the bolts to the tranny the motor locks up and won't turn over.

    2003 Mitsubishi Montero Sport

    -

    Maintenance & Repair

  • Montero Sport Sputtering 14 Answers

    My 2003 Montero sport sputtering when I slow down and accelerate. Sometimes it sputters when I'm stopped at a light……What is wrong?

    2003 Mitsubishi Montero Sport LS 4WD

    -

    Maintenance & Repair

  • 03 Montero Sport dying 1 Answer

    My Montero Sport idles fine just under 1000 RPM's but once you attempt to drive it the RPM's drop to 0 and it dies. What could be causing this?

    2003 Mitsubishi Montero Sport

    -

    Maintenance & Repair

  • 2003 Montero Sport Sputters in idle or stop signs but does not stall 2 Answers

    2003 Montero Sport Sputters in idle or stop signs but does not stall. O2 sensors replaced not long ago. Check engine light went on in car wash. Car has bad oil leak

    2003 Mitsubishi Montero Sport XLS 4WD

    -

    Maintenance & Repair

  • Mitsubishi Montero sport problem 2 Answers

    My 2000 Mitsubishi Montero sport starts and runs for about 4 minutes and then it bogs out and then some smoke comes from the bottom of the engine and hits the exhaust this all happened when I cut...

    2000 Mitsubishi Montero Sport ES

    -

    Maintenance & Repair

Shortcuts

Search Mitsubishi Montero Sport Questions

CarGurus Experts

  • #1
    Jared Chase
    Reputation
    1,550
  • #2
    Daniel Foster
    Reputation
    950
  • #3
    mikeatpriestlake
    Reputation
    470
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Toyota 4Runner
15 Great Deals out of 301 listings starting at $9,995
Used Mitsubishi Outlander
44 Great Deals out of 1,689 listings starting at $3,995
Used Toyota Tacoma
45 Great Deals out of 1,079 listings starting at $9,399

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.