My friend has a 2003 Chevy Silverado 3500 with the LB7 Duramax in it. It has a ton of upgrades done to it and we needed more fuel, added upgrade and sputtering
2,105

Asked by Jeremy Oct 21, 2012 at 04:38 PM about the 2003 Chevrolet Silverado 3500 LS Extended Cab LB DRW RWD

Question type: Car Customization

We added a Raptor 150 fuel pump to the truck along with the stock pump. We made sure that all the lines were in check and
everything turned out fine. But when we started the truck and tried to put his DSP5 switch in his extreme setting, and put the
throttle about half way down, the truck started cutting in and out. So, we tried a different setting. His fuel econ mode, and it cut
out in it too. Every setting we tried it started cutting in and out. It would still drive, but you hardly had any power. It also hazed
at light throttle. The only way you could get good performance out of it was if you turned the key on and off to let the pump
push more fuel to the engine and then start it. That would only last for a few seconds though. I guessed it was a bad pump, am I
wrong???

4 Answers
69,945

John answered 12 years ago

The pump can't surpass the injectors capabilities. If enough modifications have been done then the computer needs to be flashed for the extra air so it can compensate with the fuel and if that doesn't help then you may need higher pressure injectors because the ones you have aren't handling the higher compression ratio, which isn't likely but still possible. Take it to a performance shop to have it dyno tuned.

1 people found this helpful.
Best Answer Mark helpful
395

Keith answered 11 years ago

i'll prolly be wrong but you put a petrol pump into a diesel. i think the pump cant take the viscosity of diesel fuel. the only reason i think that, is cause if you put diesel in a petrol engine it clogs up the fuel filter

Mark helpful
69,945

John answered 11 years ago

It's a different pump he is referring to bud, he is talking about the high pressure pump.

Mark helpful
10

GuruVPT6W answered 6 years ago

I have a 2003 Chevy 2500HD with a Duramax diesel LB7 and recently added a FASS fuel system with pump and two filters. Diesel shop could not get it to work properly and found the OEM sending unit in the fuel tank had a small air leak and fuel was cavitating. Guess it's been doing it for 15 years. Ordered and installed a FASS Suction Tube kit for the fuel tank and all is well. Running great. FASS also has a Duramax Filter Delete that replaces the OEM fuel filter(DFD-4000). My 2 cents but may want to check out the FASS system and the Suction Tube Kit (STK-1003).

1 people found this helpful.
Mark helpful

Your Answer:

Related Questions

  • My friend has a 2003 Chevy Silverado 3500 with the LB7 Duramax in it. It has a ton of upgrades done to it and we needed more fuel, added upgrade and sputtering 4 Answers

    We added a Raptor 150 fuel pump to the truck along with the stock pump. We made sure that all the lines were in check and everything turned out fine. But when we started the truck and tried to put hi...

    2003 Chevrolet Silverado 3500 LS Extended Cab LB DRW RWD

    -

    Car Customization

  • 2002 chevy silverado cab swap 1 Answer

    hey there i'm looking to change out my entire cab on my chevy silverado (2002) any where i should start looking? or if a 2000-2005 cabs could be swapped on my frame? thanks!

    2002 Chevrolet Silverado 3500 LS Extended Cab LB DRW RWD

    -

    Car Customization

  • 2016 chev bed on a 2001? 4 Answers

    What will the body lines of a 2016 box look like if mounted on a 2001 chev truck? The 07-14 lines wont work at all, but the 2016 lines look similar.

    2001 Chevrolet Silverado 3500 LT Crew Cab LB DRW 4WD

    -

    Car Customization

  • Lift kits? 1 Answer

    Suggestions on a 6" (or bigger) lift kit. 2001 Silverado 3500 Note: Is a 4WD Dually.

    2001 Chevrolet Silverado 3500 LS LB DRW 4WD

    -

    Car Customization

  • Motor swap 1 Answer

    Will the top end of a newer 99 Chevrolet extended cab 1500 Silverado with the vortec motor fit on bottom half of a 95 Chevrolet extended cab 3500 dually

    Chevrolet Silverado 3500

    -

    Car Customization

Silverado 3500

Looking for a Used Silverado 3500 in your area?

CarGurus has 1 nationwide Silverado 3500 listings and the tools to find you a great deal.

Postal Code:

Shortcuts

Search Chevrolet Silverado 3500 Questions

CarGurus Experts

  • #1
    casper271
    Reputation
    160
  • #2
    GuruZBY57
    Reputation
    90
  • #2
    Rowefast
    Reputation
    90
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Chevrolet Silverado 2500HD
27 Great Deals out of 1,241 listings starting at $9,500
Used Ford F-350 Super Duty
38 Great Deals out of 2,698 listings starting at $6,996
Used Chevrolet Silverado 1500
195 Great Deals out of 5,877 listings starting at $2,975
Used GMC Sierra 2500HD
21 Great Deals out of 1,519 listings starting at $5,500
Used Dodge RAM 3500
28 listings starting at $14,999
Used Ford F-250 Super Duty
18 Great Deals out of 1,178 listings starting at $8,995
Used Ford F-150
309 Great Deals out of 13,933 listings starting at $1,712
Used Dodge RAM 2500
17 listings starting at $7,900

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.