wont stay running

Asked by rex_20 Mar 09, 2015 at 11:17 AM about the 1991 Ford F-150 XL 4WD LB

Question type: General

i have a 91 ford f150 with a 302 5.0 litter engine. filled up tank and wouldnt start, got a test ignition module and it fired up but had to put foot on the gas pettel. so put a used module on it and it ran fine for anout a week and then started doin the same thing after i filled the tank back up. so i put a new one on and drove it and during test drive it died obn me three times. So i put a new stater in it and made sure timing was good and it started but ran horrible could barly get out of its own way. So made it home and went to drive it morning after and made it to the end of my road and it died and would start but had to put foot on gas and when i put it in gear would die like it was running out of gas. Put new iac and made it about two miles and it did same thing. So i puit gas in my rear tank and it would run fine for about two minutes and started running ough. Almost made it home and it died. Got it home and now on both tanks itll run ok fo a couple minutes but then starts running rough and when put it under a load it acts like it wonts to die. Checked fuel preassure and it is great and i am getting plenty of fuel at the rail, so im thinking i have a spark issue.

2 Answers
74,390

OJ answered 9 years ago

Not sure with the 91 F150, but my 2010 was doing the same thing. It threw a code indicating there was a problem with the EVAP system. Visually check the gas tank and make sure you did not pull a vacuum on it while driving causing it to collapse. Hard starting after fillups indicates you overfilled the tank causing liquid gas to flow into the charcoal canister. It's easy to check. Remove the canister and look for fuel, there should be none. Then check hoses for leaks or kinks. If there is a code you are going to have to have it removed. Disconnecting the battery will not erase it from the memory, you'll need a scanner. Additionally, upon checking, there were two updates to my 2010 f 150's PCM which had to be installed.

2 people found this helpful.
Mark helpful
74,390

OJ answered 9 years ago

Forgot. If small charcoal pellets fall out of the canister when you check it you got raw fuel in there at one time of another. Replace it. Make sure none got sucked up in the line toward the engine.

Mark helpful

Your Answer:

Related Questions

  • wont stay running 2 Answers

    i have a 91 ford f150 with a 302 5.0 litter engine. filled up tank and wouldnt start, got a test ignition module and it fired up but had to put foot on the gas pettel. so put a used module on it and i...

    1991 Ford F-150 XL 4WD LB

    -

    General

  • Truck won't stay running 6 Answers

    I have a 1987 ford f150 5.0L recently I had to jack the motor up and change the oil pump ever since then the truck won't stay running no longer than a minute. It'll crank up and after a few secon...

    1987 Ford F-150 XL Standard Cab SB

    -

    General

  • Truck will not stay running after tune up 1 Answer

    I have a 1990 Ford F150. With a 5.0 V8. After I did a full-on tune up and put brand new Straight dual exhaust system on the truck it will start up with starting fluid but will not stay running unle...

    1990 Ford F-150 XL 4WD SB

    -

    General

  • why wont truck stay running? 3 Answers

    have a 1976 f150 4wd with a 390. the truck turns over and fires but wont stay running unless you keep the key turned. as soon as u let off it dies. have changed the cylenoid, tested the ignition mod...

    1976 Ford F-150

    -

    Maintenance & Repair

  • My ford f150 will not stay running unless I keep my foot on gas pedal 4 Answers

    Ford f150 won't stay running I

    1990 Ford F-150 XL 4WD LB

    -

    General

Shortcuts

Search Ford F-150 Questions

CarGurus Experts

  • #1
    OJ
    Reputation
    42,600
  • #2
    Gene Arnett
    Reputation
    16,040
  • #3
    Rowefast
    Reputation
    15,890
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used GMC Sierra 1500
122 Great Deals out of 6,519 listings starting at $3,975
Used Ford F-250
4 listings
Used Ford Mustang
55 Great Deals out of 1,343 listings starting at $4,995
Used Ford Ranger
26 Great Deals out of 1,573 listings starting at $3,995
Used Ford Explorer
71 Great Deals out of 2,045 listings starting at $3,995
Used Ford Bronco
26 Great Deals out of 1,248 listings starting at $37,000

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.