I have a 95 S10 with a 4.3 vortecand a cpi fuel injection. I've replaced everything but the fuel lines and It won't start. The pump only primes it to 22psi. Any help?

Asked by skybikertony Jul 09, 2016 at 06:18 PM about the 1995 Chevrolet S-10 LS Extended Cab RWD

Question type: Maintenance & Repair

I can start the truck when I pour gas into it. But only for a second.  It with
crank fine but won't start.  It only gains to 22psi when I turn on the switch.
  Every thing tells me it should be 52 psi to 60 psi.
I can't get the fuel pump to activate with the test wire under the hold it's
been down a month and I've spent $500 on it already any help would be
appreciated.

61,205

Andrew answered 8 years ago

You need at least 50 psi to fire the injectors. It's supposed to be between 55 and 65psi. Either your pump is weak, the regulator on the back of the injector spider is leaking/bad or the lines inside the plenum are bad. 22psi will not run the truck

1 people found this helpful.

Mark helpful

Your Answer:

I have a 95 S10 with a 4.3 vortecand a cpi fuel injection. I've replaced everything but the fuel lines and It won't start. The pump only primes it to 22psi. Any help? 1 Answer

I can start the truck when I pour gas into it. But only for a second. It with crank fine but won't start. It only gains to 22psi when I turn on the switch. Every thing tells me it should be 52 ...

1995 Chevrolet S-10 LS Extended Cab RWD

-

Maintenance & Repair
hello i have a 91 s10 with the 4.3 v6 the truck ran great with a broken motor mount on the driver side but after replacing it the truck wont start motor is getting gas fire and air PLEASE HELP 2 Answers

4.3 v6 with 3k+ miles ran great did full tune up still ran great then i replaced the driver side motor mount and it wouldn't start i used a jack to lift the motor to replace the broken mount im gett...

1991 Chevrolet S-10

-

Maintenance & Repair
i have a 1991 s-10, i have replaced the fuel pump but it still wont start. 7 Answers

It was spitting and sputtering bad. I changed the fuesl pump and fuel filter. Still wont start. Getting fire but wont pump gas correctly

Chevrolet S-10

-

Maintenance & Repair
I have a 1994 chevy s10 v6 that wont start checked fuel pump and to see if it had spark all checked out ok if I pour gas into the intake truck starts can anyone help? 5 Answers

1994 Chevy S10 2wd Truck V6 has spark and fuel pump seems to be working it but wont start if I pour gas in the intake it starts but dies can anyone help?

1994 Chevrolet S-10

-

Maintenance & Repair
I have a 1987 Chevy Pickup with a crate engine. I start it and it runs for about 15 -20 seconds and then shuts off. I have replace the air intake hoses, fuel lines, fuel filter. When it was turned on then started to idle low i dumped gas into it and it shut off immediately. Could it be getting too much gas? Would that mean the carb is clogged possibly? 4 Answers

I have a 1987 Chevy Pickup with a crate engine. I start it and it runs for about 15 -20 seconds and then shuts off. I have replace the air intake hoses, fuel lines, fuel filter. When it was turned ...

1987 Chevrolet S-10 Sport LB 4WD

-

Maintenance & Repair

Used Ford Ranger

26 Great Deals out of 1,576 listings starting at $2,888

Used Toyota Tacoma

57 Great Deals out of 1,042 listings starting at $8,708

Used Dodge RAM 1500

4 Great Deals out of 73 listings starting at $500

Used Ford F-150

315 Great Deals out of 15,266 listings starting at $1,712

Used GMC Sierra 1500

128 Great Deals out of 7,142 listings starting at $3,950

Used Dodge Dakota

21 listings starting at $3,999

Used Chevrolet Corvette

30 Great Deals out of 1,057 listings starting at $15,871

Used Chevrolet Blazer

19 Great Deals out of 857 listings starting at $19,499

Used Chevrolet Tahoe

20 Great Deals out of 924 listings starting at $11,900

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.

I have a 95 S10 with a 4.3 vortecand a cpi fuel injection. I've replaced everything but the fuel lines and It won't start. The pump only primes it to 22psi. Any help?

1 Answer

Your Answer:

Shortcuts

Search Chevrolet S-10 Questions

CarGurus Experts

Find great deals from top-rated dealers

Related Models For Sale

I have a 95 S10 with a 4.3 vortecand a cpi fuel injection. I've replaced everything but the fuel lines and It won't start. The pump only primes it to 22psi. Any help?

1 Answer

Your Answer:

Related Questions