1986 Starter

Asked by Terry Aug 12, 2018 at 09:21 AM about the 1986 Ford F-150 STD Standard Cab 4WD SB

Question type: Maintenance & Repair

Starter just clicks, Bought a rebuilt same thing, new solenoid same thing. Put
starter in a vise and tired using a battery same thing. If I push down on that
part that pushes out the pinon it works. I can just push a little, the pinion gear
does not even move and the starter will work. Is there some kind of voltage
increase somewhere in the wiring that gives that electromagnetic a boast to
get the gear to pop out. Tried boost 50 amp on my charger and it acted the
same way. We were trying to figure out if some of the cables to the starter
are bad is why we tested out of the truck. We bought the truck not running,
we have the distributor back in, the water pump, thermostat etc back in. We
were to  the point where we would see if it ran. LOL

1 Answer
9,760

Mike answered 6 years ago

Very common problem with that type starter, check the voltage at the starter stud on starter if it's below 12.2 check battery and cables that flipper you're pushing on goes through a field coil that needs a lot of current from the battery If you're checking on the car put pos test lead on starter stud and neg lead to a good engine ground try to crank engine check voltage if it clicks move neg test lead to battery neg terminal is the reading higher if yes it's a bad battery cable. Do youknow how to perform a voltage drop test if so you can locate the bad cable hope this helps

1 people found this helpful.
Mark helpful

Your Answer:

Related Questions

  • 1986 Starter 1 Answer

    Starter just clicks, Bought a rebuilt same thing, new solenoid same thing. Put starter in a vise and tired using a battery same thing. If I push down on that part that pushes out the pinon it works....

    1986 Ford F-150 STD Standard Cab 4WD SB

    -

    Maintenance & Repair

  • 1986 f150 302 starter broke 4 Answers

    Just picked up a 1986 f150 302. Was a bit of work to get it started, connected the starter directly to another battery with jumper cables as the one in the truck was pretty low. When the engine sta...

    1986 Ford F-150

    -

    Maintenance & Repair

  • 1986 f150 starter won't stop -- help!? 15 Answers

    KerryLL 57 seconds ago. We have an 86 f150 and we have replaced the solenoid( twice) alternator, battery ,starter, and ignition switch . when we go t...

    1986 Ford F-150

    -

    Maintenance & Repair

  • starter 3 Answers

    Where's the starter silenode

    2007 Ford F-150 XL SuperCab 4WD

    -

    Maintenance & Repair

  • Starter 1 Answer

    Will a starter from a 92Ford Ranger fit a 92 Ford F150

    1992 Ford F-150

    -

    Maintenance & Repair

Shortcuts

Search Ford F-150 Questions

CarGurus Experts

  • #1
    OJ
    Reputation
    42,600
  • #2
    Gene Arnett
    Reputation
    16,040
  • #3
    Rowefast
    Reputation
    15,890
View All

Find great deals from top-rated dealers

Search

Related Models For Sale

Used Ford F-250
4 listings
Used Ford Mustang
61 Great Deals out of 1,349 listings starting at $4,995
Used Ford Ranger
25 Great Deals out of 1,579 listings starting at $5,400
Used Ford Bronco
23 Great Deals out of 1,255 listings starting at $37,000

Content submitted by Users is not endorsed by CarGurus, does not express the opinions of CarGurus, and should not be considered reviewed, screened, or approved by CarGurus. Please refer to CarGurus Terms of Use. Content will be removed if CarGurus becomes aware that it violates our policies.